Search | MercedesSource Kits | Body and Exterior Trim (2024)

On Demand Video

$4.99

Extreme Detailing Part 4: Cleaning and Detailing an Engine Compartment Safely - On Demand Video

Kent will show you how to get it super clean with minimal water and overspray

In this 14-minute video instruction, you will get to see how Kent cleans and details an engine compartment in a W210 E430 using his favorite chemicals and techniques. This includes using less than a gallon of water and controlling the spray rinse so you protect sensitive electrical components.

$9.75

OM 616 OM 617 Engine Rear Crank Seal

$49.95

OM616 and OM617 Diesel Engine HIGH Pressure Injection Pump Timing Kit

Comes with HOUR LONG VIDEO instructions. Requires pressure tank for accurate and consistent results.

Kent's procedure uses the factory recommended"drip tube method" but with a "twist." He has devised a way to get accurate and consistant IP timing results while trying to get the drip tube to drip at one drip per second exactly when it should!

$12.75

Currently out of stock.

W201 Chrome Center Grill Strip

Fits all 201 chassis 190E and 190D from 1984 to 1993

Hard to find brand new center chrome strip for plastic front grill insert.

On Demand Video

$19.99

Door Hinge and Latch Lubrication Procedures - On Demand Video

With the right grease gun and lubricants you can make your doors close oh so smoothly!

Door hinge lubrication has to be one of the most neglected maintenance items on the older models. I think part of the problem stems from the fact owners don't know how to do it or don't know how to acquire the proper grease gun to lubricate those special fittings on the door hinges.

$99.75

Complete Lubrication Kit w/ Applicators in Carrying Case

Revised May 18, 2024 to now include Kent's Miracle Lube. This is your grab-n-go for all your lubrication needs on your older Benz

If you own and maintain an older car (especially 15 years and older) you must be willing to take care of its lubrication needs or you may spend big money later in repairs.

$46.95

Door Hinge Complete Lube Kit w/ Video Instructions

Do not neglect the door hinges and latches on your older Benz

Ever wish you could find a good way to lube the door hinges on your old Benz? Maybe you have seen that little fitting wondering what it is, or maybe you have heard there is a special grease gun that can inject grease into that fitting?

$26.00

W201 W124 Front Shock Strut Top Nut Special Wrench

Also works on R129 convertibles

When replacing the front struts ( shock absorbers ) on a W201 W124 or some W129 chassis it is frustrating and time-consuming trying to remove and replace the big 22 mm top nut on the front struts ( shocks ).

On Demand Video

$12.99

60x Diesel Engine Fuel Warmer Bypass Instructions - On Demand Video

For 1984 to 1995 OM601 OM602 and OM603 engines in W201, W124, W126 and W140 Chassis

Mercedes installed small fuel warmers on these engines using engine coolant to warm up the fuel just before it enters the injection pump. The idea is great - especially in cold climates, but in moderate and warmer climates it is probably not needed.

$65.00

Late W123 Most W126 Late R107 Chassis Ignition Lock Cylinder Tumbler Installation Kit w/ Video Instructions and Tools

For 1981-1989 W123 and W126 and 1986-1989 R107 560SL ONLY (see complete model list below).

If you are having problems with a sticking key a new tumbler a new tumbler and key may or may not fix your problem.

$19.50

Currently out of stock.

Heavy Duty Reinforced Rubber Jack Stand Top to Body Protecters

Best way to protect the underside of your car from rust and to keep the jack stand from slipping

Over the years Kent has used a number of different things to place on top his jack stands to prevent damage and for added security. He has even tried some of the commercially available jack stand plastic covers. Nothing has proven to work better than the special cut reinforced hose shown here.

On Demand Video

$9.99

W201 W124 W140 R129 REAR Shock Absorber Installation - On Demand Video

Full step-by-step instructions including tools needed and special tips

In this video Kent will demonstrate how to replace the REAR shocks in the chassis mentioned above. He will do this on the ground on his W124 coupeusing a floor jack, jack stands, and hand tools.

On Demand Video

$12.99

W201 W124 W140 R129 FRONT Shock Absorber Installation - On Demand Video

Full step-by-step instructions including tools needed and special tips to make the job go easier

In this video Kent will demonstrate how to replace the FRONT shocks in the chassis mentioned above. He will do this on the ground using a floor jack, jack stands, and hand tools.

On Demand Video

$18.99

Early W220 Engine Fan Motor Replacement Instructions - On Demand Video

Applies to 2000 and 2001 S500 and S430 sedans only

If you want to fix the engine fan motor or reduce the bearing noise, this is how you can do it for a little over $200. You don't need to replace the entire engine fan assembly, and you don't have to resort to buying a used one from eBay!

$3.85

Windshield Washer Squirt Nozzle Cleaning and Adjusting Tools

2 wire tool set - One to clean and one to adjust - watch video below for details

Are you tired of windshield washers sprayers that done spray straight or don't spray at all. If you can hear the pump running but no fluid is coming out the nozzles it could be the nozzle holes are plugged with dirt.

$14.75

Hirschmann Power Antenna Mast Cleaning and Lubrication Kit

Extend the life of your power antenna by cleaning and regular lubrication

"I have heard some owners complain about the unreliability of those older Hirschmann power antennas. I would say that in at least 80 percent of the few hundred antennas I have taken apart that went bad - the reason was lack of lubrication!

$84.50

DELUXE Windshield Fine Scratch Removal and Glass Deluxe Polishing Kit w/ Power Tool

WARNING! Not guaranteed to work on all scratches. WILL NOT WORK ON SAND PITS. Do finger test on wiper scratches BEFORE ordering!!! Read and see more below.

Contains all supplies and video instructions you need - including a high speed power multitool to remove very fine scratches.Purchase together and save $$$$. Ever wish you could get rid of the annoying wiper scratches on your front windshield (or rear hatch glass if you have a rear wiper)?

$49.95

Windshield Fine Scratch Removal and Glass Polishing Kit

WARNING! Not guaranteed to work on all scratches. WILL NOT WORK ON SAND PITS. Do finger test on wiper scratches BEFORE ordering!!! Read and see more below.

Contains all supplies and video instructions you need - except a multitool (see description. )Ever wish you could get rid of the annoying wiper scratches on your front windshield (or rear hatch glass if you have a rear wiper)?

On Demand Video

$15.99

How to Remove Fine Scratches from Your Car's Windshield - On Demand Video

Video instructions using Kent's glass polish kit to remove scratches with less mess and less heat!

This video will take you step by step through the process of using our glass polish kit with a multitool to remove those fine scratches from your windshield or rear hatch glass. It also works great for polishing the water and acid rain out of any glass, including shower doors!

$34.95

W124 Front Suspension Strut Upper Rubber Mount

Fits W124 sedans, coupes and wagons 1986 to 1995 EXCEPT 4MATIC (see model list below)

All these 124 chassis cars are 20 years or older. That is when rubber parts start to fail regardless of mileage. If you want to restore the factory ride and handling Kent strongly recommends you replace the top rubber mounts when you replace the shocks.

$4.75

617 Diesel Garrett T3 Turbocharger to Exhaust Manifold Metal Gasket

For all 5 cylinder turbo 300SD 300D 300CD and 300TD 1978 to 1985

New quality metal gasket as shown. Never try to reuse this gasket during turbo overhaul or replacement.

$9.75

1998 to 2006 V6 and V8 Engine Breather Cover Replacement Stainless Steel Bolt Set

For all M112 and M113 gas engines when resealing and replacing breather chamber covers on top of engine

If you own a 1998 to 2006 Mercedes with a V6 (M112) or a V8 (M113) engine this is one job you will have to deal with at some point. Just pull the top cover off your engine and look.

$9.60

OM617 Turbo Diesel Engine Timing Chain Tensioner Spring

Turbo models only 1978 to 1985 300D 300TD 300CD and 300SD

Brand new part. No instructions included. See related products below. Instructions do come with our turbo timing chain kit.

$14.85

OM615 OM616 OM617 Timing Chain Upper Guide Rail

Fits 200D 220D 240D 300D 300CD 300TD 300SD 1966 to 1985

Brand new quality part. No instructions included. Instructions do come with our timing chain kit.

$134.50

OM617 Turbo Diesel Engine Timing Chain Tensioner

Turbo models only 1978 to 1985 300D 300TD 300CD and 300SD

Brand new Febi Bilstein part. WARNING: Must be installed properly or damage can occur to the timing chain and sprockets. Kent always recommends you replace the tensioner when you install a new timing chain. NO INSTRUCTIONS. Instructions do not come with this part.

$8.95

Anti Corrosive Gel for Magnesium and Aluminum

For protecting clean and bare aluminum and magnesium engine parts

Kent has been working a long time to find a way to stop the ugly corrosion on aluminum and magnesium engine parts. Particularly valve covers and intake manifolds.

On Demand Video

$16.99

Modifying and Installing LED Dash Light Bulbs for Peak Performance - On Demand Video

Learn all Kent's tricks to getting maximum performance out of LED dash lights for W123 W126 W201 and W124

These instructions cover problems you may have with your bulb holders, how to set up the new LED bulbs to do TIGHTLY into the bulbs holders so they won't come loose and go out on you, and how to modify and experiment with the maximum brightness of an individual LED bulb.

$26.75

Diesel Fuel Injector Return Fuel Hose AND Brake Pad Service Tool

Easy way to remove and reinstall that hard to reach small injector fuel return hose and vacuum hose - AND works on brake pads too!!!

While working on the fuel injectors of a 240D this week, Kent finally decided he had had enough. After 20 years of fighting those fuel injector return hoses he decided he just had to come up with a tool to make the job easier. 2 hours later the tool was designed and the prototype made.

$32.95

Early 4 and 5 Cylinder Diesel Fuel Injector Hose and Injector Washer Kit

For fuel injector service on 220D 240D 300D 300CD 300TD and 300SD 1970 to 1985

Any time you are removing and replacing your fuel injectors you will need to change the return hose and the heat shield crush washers. If you don’t, you will have leaking hoses and possible compression leaks at the injector nozzles.

On Demand Video

$2.00

How to Clean Out Plugged Sunroof Drains on 1965 to 1995 Models

Part of Kent's $2 tip video collection. The tip will only cost $2 but you could save considerable money and grief by watching this video.

In this short 2:32 minute video Kent will show you how he firsttests the sunroof drains for blockage and thenhow he goes about cleaningout any blockage.

$35.75

1/4 Inch Drive Beam Type Super Low Torque Wrench

Very accurate for low torque settings - 0 to 9 Newton Meters or 0 - 80 inch pounds

If you are tired of "guessing" on those critical low torque settings maybe it is time to get a small torque wrench. This is the one Kent likes for super low torque settings up. It is quality made and will not cost you an arm and a leg. You can even calibrate it yourself!

$59.50

1998 to 2006 V6 and V8 Engine Breather Cover Oil Leak Fix Kit

For all M112 and M113 gas engines with leaking breather chamber covers on top of engine

$30.99

Gas Engine Spins But Won’t Start - Video Class with Kent Bergsma

Watch all seven videos in this series - and learn how to get your gas Mercedes starting and idling better.

Too many emails on this subject pretty much forced Kent to do this almost 3 hour long video class. If you are having problem starting your old 1976 to 1993 Mercedes with Bosch C.I.S. fuel injection this is a must see.

On Demand Video

$9.99

Gas Engine Spins But Won't Start Class - Session 5 On Demand Video

Kent goes over the eight reasons why the 300SE would not start and keep running

On Demand Video

$2.99

Gas Engine Spins But Won't Start Class - Conclusion On Demand Video

Kent concludes the class with another reason the 300SE would not start and shares other related problems like bad fuel injectors

On Demand Video

$2.99

Gas Engine Spins But Won't Start Class - Introduction On Demand Video

Kent explains why he did this class and what is covered

On Demand Video

$9.99

How to Use Kent's New Instrument Cluster Removal Tools - On Demand Video

Tips and tricks to get those stubborn clusters out of the dash

This video is free with the purchase of Kent's new dash cluster pull tool set. If you just want to see how he uses the tools and some tricks to get difficult clusters out you are welcome to purchase this video separately. Approximate run time is 20 minutes.

$394.00

1980 to 1985 380SL 380 SLC Steering Lock w/ Tumbler and Keys - NEW

Now with 2 matching high-security keys. Steering locks are in short supply, and reports they will not be made again.

We have been informed that there is no plan to manufacture new steering locks again for these classic cars. This will also fit the European R107 280SL.

On Demand Video

$12.99

M112 M113 Breather Cover Oil Leak Repair Instructions - On Demand Video

A repair you REALLY want to do yourself to get it done right!

If you own a 1998 to 2006 Mercedes with a V6 (M112) or a V8 (M113) engine this is one job you will have to deal with at some point. Just pull the top cover off your engine and look. Even cars with low mileage may have oil seeping out the breather covers on the top of the heads.

$34.75

R107 W116 W123 W126 W201 W124 R129 W140 Instrument Cluster Removal Tools

With Free Video Instructions - For most models from 1972 to 1999

Removing a Mercedes instrument cluster from any of the chassis listedis easy with these special "pull" tools. Many owners do not realize that the instrument cluster is just pushed into the dash panel and not held in with any bolts or screws.

$26.50

1974 to 1985 OM616 OM617 Diesel Upper Guide Rail Pin - Used

Fits 74 to 85 W123 240D 300D 300CD 300TD and W126 300SD

Guide use pin for upper guide rail at the top of the cylinder head. These often get striped out trying to remove them.

On Demand Video

$14.99

AIrmatic Suspension System Troubleshooting and Repair - On Demand Video

Learn how you can save thousands of dollars and with better results than from the dealer!

Don't be afraid to own one of these splendid airmatic models and don't be afraid to take on some of the repairs yourself. This system is no where near as complicated as the air suspension on my 300SEL 6.3 and way easier and cheaper to repair.

On Demand Video

$9.99

Modifying an Ignition Tumbler So You Can Remove it Later Without a Key - On Demand Video

Works on most but not all models from the late 1970's to the early 1990's - Read description carefully.

Wouldn’t it be grand if there was a way to remove your ignition tumbler without a key - then easily start the carusing a flat blade screw driver or needle nose pliers and drive away?

On Demand Video

$15.99

Replacing and Servicing a SNAP CAP Style Ignition Key Tumbler Assembly - On Demand Video

Revised Version: Do it yourself - save $$$ - even while sitting in the car iF you can still turn your old key. if you key is stuck you have bigger problems to contend with and will not be able to install a new tumbler.

This video is not only going to show you how to remove and replace the “SNAP cap” style tumbler, but it also going to explain the theory of operation and how to avoid certain pitfalls when doing this job yourself. And YES, there are pitfalls.

On Demand Video

$9.99

Gas Engine Spins But Won't Start Class - Session 4 On Demand Video

Kent goes out to a parking lot to try to start a W124 300E that wire fire but not run

$42.50

Snap Cap Style Ignition Tumbler Service and Replacement Deluxe Tool Kit w/ Extras

Service or replace your ignition tumbler sitting in your car with Kent's custom tools and FREE detailed video

If you have been around old Mercedes for any length of time, youhave probably run into a problem with your ignition key starting to "stick" or one that doesnot turn. This problem can leave you stranded and could cost hundreds of dollars to fix $$$.

On Demand Video

$9.99

Gas Engine Spins But Won't Start Class - Session 3 On Demand Video

Kent takes on a 190E 2.6 with neglected maintenance that won't even fire

$68.75

W201 W124 Late W126 Ignition Switch Tumbler w/ Two Keys - Tools and Video Instructions Included.

For 1984-1993 W201 and 1986-1995 124 chassis sedans, coupes and wagons. 1990 and 1991 W126 sedans and coupes with transmission lockout ONLY (models listed below).

If you are having problems with a sticking key a new tumbler a new tumbler and key may or may not fix your problem.

On Demand Video

$9.99

Gas Engine Spins But Won't Start Class - Session 2 On Demand Video

Kent continues working on a red 300CE coupe that won't start on cold mornings (watch session 1 first)

On Demand Video

$9.99

Gas Engine Spins But Won't Start Class - Session 1 On Demand Video

Kent goes after the reasons a red 300CE coupe won't start on cold damp mornings